Management Challenge # 10: When You Have an Employee Who Needs to Improve Quality

Excerpt from “The 27 Challenges Managers Face: Step-by-Step Solutions to (Nearly) All of Your Management Problems” (Jossey-Bass, the Wiley imprint in San Francisco, September 2014).

Retraining will improve just about anybody’s quality performance (reducing error rates), at least for a while, simply as a result of refreshing and refocusing, increasing awareness and mindfulness. Not to mention some of those basic bits of knowledge and skill necessary to do the job. Plus retraining sends a message that “doing it right” really matters.

Maybe the training was so good the first time, you don’t need to repeat it. Or maybe you don’t have the resources to retrain employees formally in a classroom. But you can have checklists and your regular ongoing one-on-one dialogue. The continuous reminders and reinforcement of performance coaching is a lot like regular continuous retraining.

Baffling to some managers is the employee who obviously knows exactly what she is doing and still makes lots of mistakes. She knows the task by heart. She’s done it a zillion times. Often, this is an employee who is so confident in her competence that she moves through the steps of each task almost automatically, thinking she could do it “in her sleep.” So she sometimes does. And that’s when the errors occur.

You need that employee to wake up: Keep a bright light on everything that employee does. Scrutiny alone can have a huge impact on an employee’s attention to detail: If I know someone is keeping a close eye on my performance, I am likely to keep a closer eye on it myself.

Scrutiny, though, is only step one. Don’t get stuck in another version of “staring at the numbers together”: Metrics in hand, show the employee her error rate and tell her explicitly, “Too many errors.” If the employee says, “Yes, I know. I’m trying,” and then next week you have the same conversation, then the wake-up call alone isn’t doing the trick. In that case, you need to use the metrics to develop good course-correcting feedback to help the employee figure out how to make fewer errors.

The answer is almost always, “Slow down and think about what you are doing.” The metrics should help you zero in on exactly where and when this particular employee needs to slow down and think, at least for now. That may turn out to be a moving target. That’s OK—that’s the whole point of metrics and coaching.

As you might have noticed, it’s often the speed demons who make the most mistakes. This is especially problematic in positions where the basis for performance evaluation and rewards is disproportionately weighted to productivity measures rather than quality. Indeed, quality is almost always harder to monitor and measure than productivity. Tracking quality requires regular auditing of work product, close attention to the details, and plenty of subjective judgment calls.

Quality assurance slows things down because slowing things down is how to assure quality. It’s a business judgment you have to make—and a delicate balance for you and your direct reports. They need your constant guidance and direction striking that balance: “Work on quality this week. Speed next week. Quality again the week after.”

Let’s say this week you are going to work on quality. In your regular one-on-one dialogue, start focusing on the goal of eliminating recurring errors, one by one:

  • Spend some time with this employee and together conduct an audit of her work product. Get inside the metrics, paying very close attention to the details.
  • Take it one task at a time. Review the employee’s work in progress and completed work product. Watch the employee do the task in question multiple times. Is the employee following a checklist?
  • Look at the employee’s every concrete action in the process. Check it against the best practices, step by step, concrete action by concrete action. Do a micro-gap analysis. Start coaching to fill the gaps. If needed, take each item on the checklist and break it down into smaller pieces so there is a mini-checklist for each item.
  • Every step of the way, make sure the employee is actually using the checklists. You might even encourage the employee to make notes in the margins of the checklists. Then you can use those notes and  checklists as a tool to guide your coaching conversations.
  • If the employee appears to be following best practices, start looking for pitfalls. Zero in on exactly where and when the most frequent mistakes are occurring. Try to figure out exactly what’s going wrong.
  • Choose one concrete action at a time to “make error free” and take it slowly. What if the employee could eliminate just one recurring error per week?
  • Once you’ve increased the quality of one task, move on to the next task. And so on.

Every step of the way, remember to monitor the productivity of this person’s work to make sure it doesn’t dip and acknowledge her continued high speed, even as her pace slows down just enough to dot her “i”s and cross her “t”s on that checklist.

The fact that checklists slow a person down is one of the best reasons to use them when improving quality. Checklists are not just step-by-step instructions, but also tools of mindfulness.

My lifelong mentor and Karate teacher, Master Frank Gorman, taught me this little exercise about mindfulness. He’d say: “Write your name.” Then he’d say: “OK. Now write your name, but leave out every other letter.” Then he’d say: “I cut out half your work. Why did it take you twice as long?” The answer of course is mindfulness. You have to slow down and think about what you are doing.

If you want to slow people down and get them to think about what they are doing, you need to change up the process a little now and then. Keep challenging them to keep it interesting: Focus on speed one week. Quality the next. Focus on removing errors from one task this week. Another task the next week.

Excerpt from “The 27 Challenges Managers Face: Step-by-Step Solutions to (Nearly) All of Your Management Problems” released by Jossey-Bass, the Wiley imprint in San Francisco (September 2014; $23.95). For more information, visit http://rainmakerthinking.com/books-videos/27-challenges-mangers-face-step-step-solutions-nearly-management-problems/

Based in New Haven, CT, Bruce Tulgan is a leading expert on young people in the workplace. He is an advisor to business leaders all over the world, the author or coauthor of numerous books, including the classic, “Managing Generation X” (1995); best-seller “It’s Okay to Be the Boss” (2007); “Not Everyone Gets a Trophy’ (2009); and “The 27 Challenges Managers Face” (2014). Since founding management training firm RainmakerThinking in 1993, he has been a sought-after keynote speaker and seminar leader. Follow him on twitter @brucetulgan. He can be reached at brucet@rainmakerthinking.com.

 

Training Top 125

2017 Training Top 125 winners demonstrated a strong focus on effective training and employee development tied to corporate strategic goals and business impact.

Digital Issue

Click above for Training Magazine's
current digital issue

Training Live + Online Certificate Programs

Now You Can Have Live Online Access to Training magazine's Most Popular Certificate Programs! Click here for more information.

Emerging Training Leaders

Emerging

Spectacular. Impressive. Dazzling.

Spring is—finally—in the air.

By Lorri Freifeld

ISA Directory

Twitter